China New Product Waste Water Filtration System - UF Membrane Module PVC Ultrafiltration Membrane Module UFc80C Stainless Steel Housing Rain Water Treatment – Bangmo
China New Product Waste Water Filtration System - UF Membrane Module PVC Ultrafiltration Membrane Module UFc80C Stainless Steel Housing Rain Water Treatment – Bangmo Detail:
Applications
●Production of mineral water, mountain spring water and other germ-free liquid.
●Drinking treatment of tap water, surface water, well water and river water.
●Pre-treatment of RO device.
●Treatment, recycle and reuse of industrial wastewater.
Filtration Performance
According to the service conditions of modified PVC hollow fiber ultrafiltration membrane which are applied to various water sources, the product is proved to reach below filtration effects:
| Water Composition | Filtering Effect |
| Suspended Substances, Particles >1um | Removal Rate ≥99% |
| SDI | ≤ 3 |
| Virus, Bacteria | >4 log |
| Turbidity | <0.1NTU |
| TOC | Removal Rate 0-25% |
Above data is obtained when turbidity of feed water is less than 15NTU. The product is proved to reach the sanitary standards of drinking water by Health Department of Guangdong Province. Approval number is YUE WEI SHUI ZI 2014 S1671.
Product Parameters
Product Appearance
Figure 1 Product Dimensions
Technical Parameters
| Structure | Inside-out |
| Membrane Material | Modified PVC |
| MWCO | 100K Dalton |
| Nominal Membrane Area | 16.5m2 |
| Membrane ID/OD | 1.0mm/1.8mm |
| Module Dimensions | Φ180mm×1382mm |
| Connector Dimensions | DN25 Female Thread |
Application Data
| Pure Water Flux | 7,000L/H (0.15MPa, 25ºC) |
| Designed Flux | 35-100L/H (0.15MPa, 25ºC) |
| Operating Pressure | ≤0.2MPa |
| Maximum Trans Membrane Pressure | 0.2MPa |
| Maximum Operating Temperature | 45ºC |
| Operating PH Range | 4-10 |
| Washing PH Range | 2-12 |
| Operating Mode | Cross-flow/Dead-end Filtration |
Feed Water Requirements
A security filter, precision <50 micron, should be set as pretreatment of UF, in case of blockage caused by large particles in raw water. Attention: UF membrane material is macromolecular organic plastics, raw water must not contain any organic solvents.
| Feed Water Turbidity | ≤15NTU |
| Oil & Grease | ≤2mg/L |
| Feed Water SS | ≤20mg/L |
| Total Iron | ≤1mg/L |
| Continuous Feeding Residual Chlorine | ≤5ppm |
| COD | Suggested ≤500mg/L |
Component Material
| Component | Material |
| Hollow Fiber Membrane | Modified PVC |
| Potting Material | Epoxy Resins |
| Membrane Housing | SUS304 |
Typical Operating Parameters
| Maximum Backwashing Pressure | 0.2MPa | |
| Backwashing Flow Rate | 100-150L/m2 .h | |
| Backwashing Frequency | Every 30-60 minutes | |
| Backwashing Duration | 30-60 seconds | |
| CEB Frequency | 0-4 times/day | |
| CEB Duration | 5-10 minutes | |
| CIP Frequency | 1-3 months | |
| General Washing Chemicals ： | ||
| Disinfection | 15ppm NaClO | |
| Organic Contamination Washing | 0.2% NaClo+0.1% NaOH | |
| Inorganic Contamination Washing | 1-2% Citric Acid /0.2% HCl | |
Product detail pictures:
Related Product Guide:
Sticking for the principle of Super Quality, Satisfactory service ,We have been striving for being a superb small business partner of you for China New Product Waste Water Filtration System - UF Membrane Module PVC Ultrafiltration Membrane Module UFc80C Stainless Steel Housing Rain Water Treatment – Bangmo , The product will supply to all over the world, such as: Las Vegas , South Korea , Angola , Now, we professionally supplies customers with our main products And our business is not only the buy and sell, but also focus on more. We target to be your loyal supplier and long-term cooperator in China. Now, We hope to be the friends with you.
By John biddlestone
from azerbaijan
- 2017.06.29 18:55
The factory has advanced equipment, experienced staffs and good management level, so product quality had assurance, this cooperation is very relaxed and happy!
By Marjorie
from Canada
- 2018.08.12 12:27
Write your message here and send it to us
Products categories
-
18 Years Factory Waste Water Filter System - M...
-
Factory Free sample Membrane Separation Process...
-
Factory For Ultrafiltration Unit - UF Membrane...
-
Factory wholesale Uf Filtration System - MBR M...
-
Manufacturer for Uf System Water Treatment - M...
-
Super Purchasing for Ultrafiltration Water - M...