China wholesale Membrane Biological Reactor - UF Membrane Module PVC Ultrafiltration Membrane Module UFc50C Stainless Steel Housing Household Water Purification – Bangmo

Short Description:

Product Detail

Product Tags

Feedback (2)

We will constantly satisfy our respected customers with our good excellent, superior value and superior assistance due to we're additional experienced and far more hard-working and do it in cost-effective way for Hollow Fiber Membrane Water Filter , Ultra Filtration System , Membrane Filtering , Welcome friends from all over the world come to visit, guide and negotiate.

China wholesale Membrane Biological Reactor - UF Membrane Module PVC Ultrafiltration Membrane Module UFc50C Stainless Steel Housing Household Water Purification – Bangmo Detail:

Product Overview

UFc50C is capillary hollow fiber membrane made of high polymer material, which is a separating product that will not have any phase change. The modified PVC material adopted to this product has good permeable rate, good mechanical strength, good chemical resistance anti-pollution ability, MWCO is 100k Dalton. Membrane ID/OD is 1.0mm/1.8mm, filtering direction is inside-out, that is raw water flows inside the hollow fibers and, driven by differential pressure, permeates outwards so as to filter bacteria, colloids, suspended substances, microbes, and other harmful substances.

Applications

Production of mineral water, mountain spring water and other germ-free liquid;

Drinking treatment of tap water, surface water, well water and river water;

Pre-treatment of RO device;

Treatment, recycle and reuse of industrial wastewater

Filtration Performance

According to the service conditions of modified PVC hollow fiber ultrafiltration membrane which are applied to various water sources, the product is proved to reach below filtration effects:

Water Composition	Filtering Effect
Suspended Substances, Particles >1um	Removal Rate ≥99%
SDI	≤ 3
Virus, Bacteria	>4 log
Turbidity	<0.1NTU
TOC	Removal Rate 0-25%

Above data is obtained when turbidity of feed water is less than 15NTU. The product is proved to reach the sanitary standards of drinking water by Health Department of Guangdong Province. Approval number is YUE WEI SHUI ZI 2014S1671.

Product Parameters

Product Appearance

svdd
Figure 1 Product Dimensions

Inner Filter

bfd

Figure 2 Inner Filter Dimensions

Technical Parameters:

Structure	Inside-out
Membrane Material	Modified PVC
MWCO	100K Dalton

Nominal Membrane Area	5.4m
Membrane ID/OD	1.0mm/1.8mm
Module Dimensions	Φ105mm× 1110mm
Connector Dimensions	3/4” Female Thread

Application Data:

Pure Water Flux	1,700L/H (0.15MPa, 25ºC)
Designed Flux	35-100L/H (0.15MPa, 25ºC)
Operating Pressure	≤0.2MPa
Maximum Trans Membrane Pressure	0.2MPa
Maximum Operating Temperature	45ºC
Operating PH Range	4-10
Washing PH Range	2-12
Operating Mode	Cross-flow/Dead-end Filtration

Feed Water Requirements:

A security filter, precision <50 micron, should be set as pretreatment of UF, in case of blockage caused by large particles in raw water. Attention: UF membrane material is macromolecular organic plastics, raw water must not contain any organic solvents.

Feed Water Turbidity	≤15NTU
Oil & Grease	≤2mg/L
Feed Water SS	≤20mg/L
Total Iron	≤1mg/L
Continuous Feeding Residual Chlorine	≤5ppm
COD	Suggested ≤500mg/L

Component Material:

Component	Material
Hollow Fiber Membrane	Modified PVC
Potting Material	Epoxy Resins
Membrane Housing	SUS304

Typical Operating Parameters:

Maximum Backwashing Pressure		0.2MPa
Backwashing Flow Rate		100-150L/m2 .h
Backwashing Frequency		Every 30-60 minutes
Backwashing Duration		30-60 seconds
CEB Frequency		0-4 times/day
CEB Duration		5-10 minutes
CIP Frequency		1-3 months
General Washing Chemicals ：
Disinfection	15ppm NaClO
Organic Contamination Washing	0.2% NaClo+0.1% NaOH
Inorganic Contamination Washing	1-2% Citric Acid /0.2% HCl

Product detail pictures:

Related Product Guide:

We have been convinced that with joint attempts, the business enterprise between us will bring us mutual benefits. We could guarantee you product or service good quality and aggressive value for China wholesale Membrane Biological Reactor - UF Membrane Module PVC Ultrafiltration Membrane Module UFc50C Stainless Steel Housing Household Water Purification – Bangmo , The product will supply to all over the world, such as: Bhutan , Israel , moldova , We are trying our to make more customers happy and satisfied. we sincerely hope to establish a good long-term business relationship with your esteemed company thought this opportunity,based on equal, mutual beneficial and win win business from now till the future.

Mbr Technology